Section 422.132. Wood door coating.

 

(1)   Applicability.

(am) Except as provided in par. (bm) , this section applies to the wood entry or passage door coating lines of any wood entry or passage door coating facility that is either of the following:

1. Located in the county of Kenosha, Milwaukee, Ozaukee, Racine, Washington, or Waukesha and which has maximum theoretical emissions of VOC from all wood entry or passage door coating at the facility greater than or equal to 25 tons per year.

2. Located in the county of Kewaunee, Manitowoc, or Sheboygan and which has maximum theoretical emissions of VOC from all wood entry or passage door coating at the facility greater than or equal to 100 tons per year.

(bm) This section does not apply to either of the following:

1. Flat wood panel coating lines subject to s. NR 422.13 .

2. Adhesives and adhesive primers subject to s. NR 422.127 .

(2)   Emission limitations and application requirements.

(a) No owner or operator of an automated wood entry or passage door coating line may cause, allow or permit the emission of any VOCs in excess of:

1. 0.77 kilograms per liter (6.9 pounds per gallon) of coating, excluding water, delivered to an applicator that applies any coating on or after May 31, 1995, but before May 1, 1997.

2. 0.64 kilograms per liter (5.7 pounds per gallon) of coating, excluding water, delivered to an applicator that applies any coating on or after May 1, 1997.

(b) An owner or operator of a wood entry or passage door coating facility shall only apply coatings using electrostatic application, flow coating, dip coating, a low-pressure spray method, paint brush, hand roller or roll coater. All applications equipment shall be in proper operating condition and used in accordance with proper operating procedures.

(3)   Recordkeeping requirements. Any facility subject to this section shall comply with the requirements applicable under s. NR 439.04 (5) .

Cr. Register, August, 1994, No. 464 , eff. 9-1-94; r. and recr. (1) (c), Register, August, 1995, No. 476 , eff. 9-1-95; CR 11-005 : renum. (1) (intro.) to be (1) (am) (intro.) and am., r. (1) (a), cr. (1) (am) 1., 2., (bm) (intro.), renum. (1) (b), (c) to be (1) (bm) 1., 2. Register January 2012 No. 673 , eff. 2-1-12.